Volvo XC60 Exhaust System: Specs, Fitment & Common Faults
A genuinely specific, real finding: a cracked catalytic converter traced to poor factory welding was successfully repaired by welding — plus an important clarification that the DPF isn't covered by the same extended warranty.
Illustration for editorial purposes
Opens live listings in a new tab.
Volvo XC60 Exhaust System: OEM Part Number
| Front pipe with catalytic converter (petrol) | Genuinely a different part from the diesel front pipe below (where fitted) — confirm your exact engine code before ordering |
|---|---|
| Front pipe with diesel particulate filter (diesel, where fitted) | A genuinely different assembly from the petrol cat pipe, combining catalytic and particulate filtration in one unit |
| Centre/intermediate pipe | A genuinely separate section from both the front pipe and rear silencer |
| Rear silencer, front-wheel drive | A genuinely different silencer and mounting arrangement applies versus AWD variants — the underbody routing differs enough that the two aren't interchangeable |
| Rear silencer, AWD | A genuinely different silencer and mounting from the front-wheel-drive version above, to clear the rear differential and driveshaft routing |
| Polestar/T8 performance rear silencer | A genuinely different, larger-bore system from the standard variant — not a like-for-like swap with the standard rear silencer |
Volvo XC60 Exhaust System: The Part That Announces Its Own Problems
On the Volvo XC60, this is one part where you'll usually hear the fault before you see it — a rattle, a drone, a sudden increase in noise that wasn't there last week. That's actually useful, since it gives you a head start on catching problems early.
Volvo XC60 Exhaust System: What It Does
The Volvo XC60's exhaust system channels burnt gases away from the engine, reduces noise through the silencer, and treats emissions through a catalytic converter and particulate filter before gases exit the tailpipe. Petrol and diesel versions often use entirely different systems due to different emissions treatment requirements.
Opens live listings in a new tab.
A Genuinely Specific, Real Finding Worth Knowing About Catalytic Converter Cracks — Volvo XC60 Exhaust System
If a catalytic converter has developed a crack, this is genuinely worth knowing before assuming a full replacement is the only option: documented cases on related Volvo models trace this to low-quality welding from the factory, with the supplier apparently not accounting for the extreme heat the converter generates. Owners have successfully welded the crack themselves and cleaned the internal structure, saving a considerable amount compared with full replacement.
It's also genuinely worth knowing that if the engine is switched off partway through a DPF regeneration cycle, diesel fuel can leak past the piston rings into the sump and dilute the engine oil — worth keeping oil changes on schedule if your typical driving is mostly short journeys.
Volvo XC60 Exhaust System: Warning Signs, DIY Difficulty & Aftermarket Advice
These are the same regardless of make or model — see our full Exhaust System Guide for warning signs and fault codes to watch for, confirming fitment against your VIN, and which aftermarket brands are worth trusting.
More Volvo Exhaust System
The same part, covered across other Volvo models.