Peugeot Partner Brake Discs: Specs, Fitment & Wear Symptoms

On the Partner, a genuine, dealer-confirmed fault causes brakes to overheat by not releasing fully — plus a real story of how cleaning and hard braking saved a full disc replacement bill.

Illustration for editorial purposes

Find Peugeot Partner Brake Discs Here!

Opens live listings in a new tab.

OEM Part Number: confirm via VIN — front discs (aftermarket) Brembo 09.9619.11 / Bosch 0 986 478 979

Accuracy note: Covers the Peugeot Partner (2008-2018) as listed in the UK aftermarket catalogues. Front brake discs are sold by diameter and thickness, and most models have two or three disc sizes depending on engine, brake size and trim — a 278 mm disc will not fit a car built with 300 mm brakes, so the caliper carrier and the disc must match. The references below are UK aftermarket catalogue listings for this generation, labelled by brand with diameter x thickness in mm; genuine numbers are shown only where a listing quotes one. Measure the old disc or check the brake size against your VIN before ordering, replace discs in pairs with new pads, and scrap any disc at or below its minimum thickness.

Front brake discs (aftermarket)	Brembo 09.9619.11 (283 x 26 mm, vented, 4 holes, coated, min 24 mm); Brembo 09.8760.11 (283 x 26 mm, vented, 4 holes, coated, min 24 mm); Bosch 0 986 478 979 (282.6 x 26.1 mm, vented, 4 holes, coated, min 24 mm); TRW DF4183 (283 x 26 mm, vented, 4 holes, painted, min 24 mm); ATE 24.0126-0120.1 (283 x 26 mm, vented, 4 holes, coated, min 24 mm); febi 21121 (283 x 26 mm, vented, 4 holes, coated, min 24 mm); TRW DF4184 (266 x 22 mm, vented, 4 holes, painted)
Disc sizes & variants	283 x 26 mm is the main front disc on the 4-stud Partner Tepee; a smaller 266 x 22 mm disc (TRW DF4184, Ridex 82B0015, min 20 mm) is listed for the lowest-output versions. Shared with the Citroen Berlingo B9.
Genuine (OE) numbers quoted	None quoted in catalogue listings — order genuine discs against your VIN
Fitment notes	Minimum thickness 24 mm (283) and 20 mm (266); check stud count and measure the fitted disc before ordering.

A Genuine, Confirmed Fault: Brakes That Don't Fully Release — Peugeot Partner Brake Discs

If you're noticing a burning smell, a wheel that feels unusually hot after driving, or a wheel making noise that comes and goes seemingly at random, this is worth checking directly before assuming worn discs or pads: a genuine, dealer-confirmed fault exists where the brakes don't release fully from the disc after being applied, causing exactly this kind of overheating on one or more wheels. This has been documented as an out-of-warranty repair even on cars only around 1.5 years old, with a labour cost commonly in the £60-80 range. If you notice a wheel running hot or smelling of brakes after ordinary driving, it's worth raising this specific fault by name with a technician rather than assuming it's simply wear.

A genuine, real story worth knowing before paying for a full disc replacement: one owner was told at just 20,000 miles that an apparently warped front disc needed both discs and pads replaced, since it wasn't considered a warranted part. Before paying for this, they tried cleaning the pads and reapplying copper grease, then took the car for a drive specifically doing several rounds of hard braking once it was safe to do so — this resolved the vibration completely and saved what would otherwise have been a substantial bill. Rust building up on a disc's clean, unworn area (common on lower-mileage cars, or after the car's been standing in wet weather) can produce a vibration that feels exactly like a warped disc but isn't one.

Peugeot Partner Brake Discs: Watch: Replacing It

🎬 Watch: Citroen Berlingo / Peugeot Partner Front Disc and Pads Replacement (2015-2018)

Watch on YouTube ↗

Berlingo twin, covers Partner B9 front discs and pads.

Peugeot Partner Brake Discs reference plate

Peugeot Partner Brake Discs: The Part That Pads Depend On

On the Peugeot Partner, discs and pads work as a pair, and neglecting one tends to accelerate wear on the other — which is exactly why worn discs so often get discovered during what was meant to be a routine pad change.

Before you buy: disc size and design vary by trim, engine size and whether your car has the standard or "sport" brake package. Always confirm against your VIN before ordering.

Peugeot Partner Brake Discs: What They Do

Brake discs provide the surface the brake pads clamp against to slow the car, converting momentum into heat through friction. Larger, sportier trims of the Partner typically use bigger discs than standard versions to handle the additional heat generated by more aggressive braking.

Find Peugeot Partner Brake Discs Here!

Opens live listings in a new tab.

Peugeot Partner Brake Discs: Wear Symptoms, DIY Difficulty & Aftermarket Advice

These are the same regardless of make or model — see our full Brake Discs Guide for warning signs to watch for, confirming fitment against your VIN, and choosing a reliable aftermarket disc.

More Peugeot Brake Discs

The same part, covered across other Peugeot models.